Efficient FPGA-based phase measurement for heterodyne interferometry
DOI:
https://doi.org/10.4108/dtip.13625Keywords:
Custom low-cost FPGA, high-speed ADC, vibration and displacement measurementAbstract
INTRODUCTION: Phase measurement plays an important role in high-precision applications such as optical interferometry, metrology, and scientific instrumentation, where accurate and low-latency phase information is required.
OBJECTIVES: This paper presents a real-time phase difference measurement system implemented on a low-cost Kintex-7 (XC7K325T) FPGA.
METHODS: The proposed system directly estimates the instantaneous phase difference between two heterodyne signals using a feed-forward quadrature processing approach. Each input signal is processed with filtering and the Hilbert transform to obtain the in-phase and quadrature components, followed by amplitude normalization to reduce the influence of variations in signal magnitude. The phase difference is then computed by quadrature mixing to generate sine and cosine components, which are converted to phase values using a CORDIC-based arctangent module. The entire signal processing chain is implemented in a fully pipelined FPGA architecture, enabling deterministic, low-latency real-time operation.
RESULTS: Experimental results using controlled heterodyne signals generated by a Moku: Lab instrument demonstrate that the proposed system provides accurate phase measurements with a small, consistent offset (approximately 1.2°) and an end-to-end processing latency of approximately 420 ns.
CONCLUSION: The proposed fully pipelined FPGA architecture is suitable for deterministic, low-latency real-time phase measurement in interferometric systems.
Downloads
References
[1] Birbacher T, Glauser AM, Ranganathan M, Quanz SP. A sub-nanometer long-term stable heterodyne laser metrology system for the Nulling Interferometry Cryogenic Experiment. 2022;47. doi:10.1117/12.2631654.
[2] Dong NT, Tai NT, Hoang DV, Mai NTP, Tung VT, Thang VT. Sub-nanometer displacement measurement using heterodyne interferometer and down-beat frequency technique. Lecture Notes in Mechanical Engineering. 2022:1170-1176. doi:10.1007/978-981-19-1968-8_98.
[3] Hsu MTL, Littler ICM, Shaddock DA, Herrmann J, Warrington RB, Gray MB. Subpicometer length measurement using heterodyne laser interferometry and all-digital RF phase meters. Optics Letters. 2010; 34(24): 4202-4204. doi: 10.1364/OL.35.004202.
[4] Tung VT, Thang VT. High precision displacement-measuring interferometer based on phase modulation technique and modulation index effect elimination. IOP Conf Ser Mater Sci Eng. 2020;715(1):012086. doi:10.1088/1757-899X/715/1/012086.
[5] Xie J, Liao H, Yan L, Chen B, Lou Y, Chen H, Guo G. Precision vibration measurement using differential phase-modulated homodyne interferometry. Optics and Lasers in Engineering. 2023; 169: 1-9. doi: 10.1016/j.optlaseng.2023.107695.
[6] Zhao Z, Hu Y, Chen S. A review: phase measurement techniques based on metasurfaces. Photonics. 2024;11(11):996. doi:10.3390/photonics11110996.
[7] Nguyen TD, Duong QA, Higuchi M, Vu TT, Wei D, Aketagawa M. 19-picometer mechanical step displacement measurement using heterodyne interferometer with phase-locked loop and piezoelectric driving flexure-stage. Sens Actuators A Phys. 2020;304:111880. doi:10.1016/j.sna.2020.111880.
[8] Nguyen TD, Higuchi M, Vu TT, Wei D, Aketagawa M. 10-pm-order mechanical displacement measurements using heterodyne interferometry. Appl Opt. 2020;59(27):8478. doi:10.1364/AO.400682.
[9] De Marcellis A, Ferri G, Palange E. A fully analog high performances automatic system for phase measurement of electrical and optical signals. IEEE Trans Instrum Meas. 2015;64(4):1043-1054. doi:10.1109/TIM.2014.2360788.
[10] Nikoofard A, Kananian S, Fotowat-Ahmady A. A fully analog calibration technique for phase and gain mismatches in image-reject receivers. AEU Int J Electron Commun. 2015;69(5):823-835. doi:10.1016/j.aeue.2015.01.014.
[11] Vera-Salas LA, Moreno-Tapia SV, Garcia-Perez A, Romero-Troncoso RJ, Osornio-Rios RA, Serroukh I, et al. FPGA-based smart sensor for online displacement measurements using a heterodyne interferometer. Sensors. 2011;11(8):7710-7723. doi:10.3390/s110807710.
[12] Reverter F, Gasulla M, Pallàs-Areny R. Analysis of power supply interference effects on quasi-digital sensors. Sens Actuators A Phys. 2005;119(1):187-195. doi:10.1016/j.sna.2004.08.027.
[13] Ferrari V, Ghisla A, Kovács Vajna Z, Marioli D, Taroni A. ASIC front-end interface with frequency and duty cycle output for resistive-bridge sensors. Sens Actuators A Phys. 2007;138(1):112-119. doi:10.1016/j.sna.2007.04.060.
[14] Reverter F. The art of directly interfacing sensors to microcontrollers. J Low Power Electron Appl. 2012;2(4):265-281. doi:10.3390/jlpea2040265.
[15] Sifuentes E, Gonzalez-Landaeta R, Cota-Ruiz J, Reverter F. Measuring dynamic signals with direct sensor-to-microcontroller interfaces applied to a magnetoresistive sensor. Sensors. 2017;17(5):1150. doi:10.3390/s17051150.
[16] Straube, G., Fischer Calderón, J.S., Ortlepp, I. et al. A Heterodyne Interferometer with Separated Beam Paths for High-Precision Displacement and Angular Measurements. Nanomanuf Metrol. 2021; 4:200–207. doi: 10.1007/s41871-021-00101-x.
[17] Gerberding O, Sheard B, Bykov I, Kullmann J, Delgado JJE, Danzmann K, et al. Phasemeter core for intersatellite laser heterodyne interferometry: modelling, simulations and experiments. Class Quantum Grav. 2013;30(23):235029. doi:10.1088/0264-9381/30/23/235029.
[18] Mitra J, Nayak TK. An FPGA-based phase measurement system. IEEE Trans Very Large Scale Integr Syst. 2018;26(1):133-142. doi:10.1109/TVLSI.2017.2758807.
[19] XC7K325T FPGA Board. AliExpress. [Online]. Available: https://vi.aliexpress.com/item/1005001275162791.html.
[20] Texas Instruments. AFE7225 Evaluation Module User’s Guide. SLOU362. Texas Instruments. [Online]. Available: https://www.ti.com/lit/ug/slou362/slou362.pdf.
[21] Texas Instruments. FMC-ADC-ADAPTER Evaluation Module. [Online]. Available: https://www.ti.com/tool/FMC-ADC-ADAPTER#tech-docs.
[22] Ngo VM, Nguyen TD. A reproducible FPGA-ADC synchronization architecture for high-speed data acquisition. Data. 2026;11(1):23. doi:10.3390/data11010023.
[23] Xilinx, Inc. CORDIC v6.0 LogiCORE IP Product Guide: Vivado Design Suite. [Online]. Available: https://www.xilinx.com.
[24] Liquid Instruments. Moku Specifications. [Online]. Available: https://download.liquidinstruments.com/documentation/specs/hardware/mokulab/MokuLab-Specifications.pdf.
Downloads
Published
Issue
Section
License
Copyright (c) 2026 Mr. Ngo Van Muoi, Assoc. Prof. Thanh Dong Nguyen, Thi Phuong Mai Nguyen
This work is licensed under a Creative Commons Attribution-NonCommercial-ShareAlike 4.0 International License.
This is an open access article distributed under the terms of the CC BY-NC-SA 4.0, which permits copying, redistributing, remixing, transformation, and building upon the material in any medium so long as the original work is properly cited.
